VR-12 MSDS

VR-12 7986 NW 14th. STREET
DORAL FL 33126 – USA
Tel: 305-640-0414
Fax: 305-640-0454
info@freezetone-usa.com
MSDS on-line: www.vr12.com

MATERIAL SAFETY DATA SHEET

VR-12 VITAMIN FOR YOUR RADIATOR
Precharged Additive package

MSDS No: VR-12/001
VR-12 VITAMIN FOR YOUR RADIATOR
Precharged Additive package
Ver. No: 1
Ver. Date: 9/05/2013
National Fire Protection Association

0 Healt
0 Flammability
0 Reactivity
0 Special

CUSTOMER SERVICE
+1-305-640-0414

Protective Equipment


Section 1 CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
Product/Chemical Name VR-12
Product Description: Inhibitor package, fully formulated and pre-charged Mixture Alkaline aqueous solution of inorganic and organic corrosion inhibitors.
Chemical Name: Mixture
Chemical Family: Mixture
Chemical Formula: None
CAS Registry: Inhibitor package for automotive antifreeze or additive package for automotive antifreeze/coolant.
Other Designations: VR-12 PRODUCTS Inc
General Use: 7986 NW 14 ST.
Manufacturer: DORAL FL 33126 Tel: 305-640-0414 Fax: 30305-640-0454 Hours of operation: Mon-Fri 8:00am-5:00pm EST) 24-hour International Emergency Number: 1-800-282-3171



Section 2
INGREDIENTE CAS NO: OSHA PEL
TOLYTRIAZOLE 7632-00-0 N/A
POTASSIUM HYDROXIDE 1310-58-3 2mg/m3
PROPRIETARY INHIBITORS N/A N/A
H2O 7732-18-5



Section 3 HAZARDOUS IDENTIFICATION


Health: 0
Flammability: 0
Reactivity: 0
Special: 0
0 = minimal 1= slight 2=moderate
3= serious 4= severe

HMIS
H # 0
F # 0
R # 0

APPEARANCE: FLORESCENT AMBER YELLOWISH
VAPOR PRESSURE (mm Hg): N/A
ODOR: CHARACTERISTIC
VAPOR DENSITY (AIR =1) N/A
EVAPORATION RATE: N/A
FREEZING POINT: 32ºF
pH: 10.2 to 11.0 (Concentrate) (9.6 Balanced)
SPECIFIC GRAVITY (H²0 =1): 1.110 – 1.125
SOLUBILITY IN WATER: COMPLETE
NITRITE: 2400 ppm min

Section 4 FIRE-FIGHTING MEASURES
Unusual Fire fighting procedures: None required; non-flammable product
Flash Point: None detected
Flash Point Method: Pensky Martens
Burning Rate: Does not burn
Auto ignition Temperature: Not available
Flammable limits in air (% by volume): Not applicable
LEL: Not applicable
UEL: Not applicable
Flammability Classification: Not flammable
Extinguishing Media: Water, fog, foam, CO , dry chemical
Unusual Fire or Explosion Hazards: Closed containers may rupture or explode due to steam pressure build-up when exposed to extreme heat. Water may be used to cool closed containers.
Fire-Fighting Instructions: Do not release runoff from fire control methods to sewers or waterways.
Fire-Fighting Equipment: Because fire may produce toxic thermal decomposition products, wear a self-contained breathing apparatus (SCBA) with a full face piece operated in pressure-demand or Positive-pressure mode.
Unusual Fire fighting procedures: Full protective equipment including self-contained breathing apparatus should be used During a fire. During emergency conditions, overexposure to decomposition products may cause a health hazard. Symptoms may not be immediately apparent. Seek medical attention

NFPA
 

Section 5 ACCIDENTAL RELEASE MEASURES
Spill/Leak Procedures: Recover usable material by convenient method; residual may be removed by wipe or wet mop
Small Spills: Small spills should be absorbed with a suitable inert material (sand, earth, clay, etc.). Remove the absorbed material and place in an appropriate chemical waste container for disposal.
Large Spills: For large spills, dike and pump into suitable containers. Clean up residual water.
Disposal Method: BIODEGRADABLE, NO CONTAMINANT, NON HAZ.
Regulatory Requirements: Follow applicable Federal, State and Local regulations.

Section 6 HANDLING, STORAGE and Transportation
Handling Precautions: Keep containers on a clean and dry storage, keep out of reach of children.
Storage Requirements: Keep containers tightly closed when not in use. If security seal is broken use the product on cooling system or discard.
Transportation Information: Product can be transported without any special handling. Make sure all Bottles are capped and all seals are unbroken. Product is Biodegradable and NON hazardous no special care is necessary.



SECTION 7 HAZARDOUS INFORMATION
EPA Regulations N/A
RCRA Hazardous Waste Number and RCRA N/A
Hazardous Waste Classification: Biodegradable NON Hazardous
CERCLA Hazardous Substance and CERCLA N/A


VR-12 DISCLAIMER.

THE INFORMATION CONTAINED HEREIN IS BASED ON THE DATA AVAILABLE TO US AND IS BELIEVED TO BE ACCURATE.
V R – 12 MAKES NO WARRANTY, EXPRESSED OR IMPLIED REGARDING THE ACCURACY OF THESE DATA OR THE RESULTS TO BE OBTAINED FROM THE USE THEREOF. VR-12 ASSUMES NO RESPONSIBILITY FROM THE USE OF THE PRODUCT DESCRIBED HEREIN.
RECIPIENTS ARE ADVISED TO CONFIRM IN ADVANCE OF NEED THAT THE INFORMATION IS CURRENT, APPLICABLE, AND SUITABLE TO THEIR CIRCUMSTANCES.
THE USAGE OF VR-12 DOES NOT REPAIR ANY DAMAGES ALREADY CAUSED OR NOTICED DUE TO A NEGLECTED COOLING SYSTEM.
DATE UPDATED: 09/02/2013


Download VR-12 MSDS